通过复合电沉积的方法制备新型三价铬镀铬用PbO2-CeO2-ZrO2惰性阳极材料,采用电化学方法测试分析电极材料的沉积机理、耐蚀性和催化活性;利用扫描电镜和能谱观察电极材料的微观形貌和元素含量.结果表明:镀层的沉积符合Johnson机理,PbO2的沉积过程非常稳定;ZrO2浓度为20g/L制备的复合惰性阳极材料耐蚀性好,催化活性高;ZrO2的加入对镀层的微观形貌影响不明显,随镀液中ZrO2浓度增大,镀层中CeO2的含量总体稳定,ZrO2的含量呈现先增大后减小的趋势.
参考文献
| [1] | DANILV F I;PROTSENKO V S;GORDIIENKO V O .Nanocrystalline hard chromium electrodeposition from trivalent chromium bath containing carbamide and formic acid:structure,composition,electrochemical corrosion behavior,hardness and wear characteristics of deposition[J].Applied Surface Science,2011,257(18):8048-8053. |
| [2] | 梁奇峰.镀铬工艺及其研究进展[J].广东化工,2007(11):67-68,8. |
| [3] | EL-SHARIF M;CHISHOLM C V .Characteristics of electrodeposited chromium[J].Transactions of the Institute of Metal Finishing,1997,75(06):208-212. |
| [4] | EL-SHARIF M;CHISHOLM C V .Electrodeposition of thick chromium coatings from an environmentally acceptable chromium (Ⅲ) glycine complex[J].Transactions of the Institute of Metal Finishing,1999,77(04):139-144. |
| [5] | 沈品华.现代电镀手册:上册[M].北京:机械工业出版社,2010:185-410. |
| [6] | 李永彦,李宁,屠振密,赵坤.三价铬硫酸盐电镀铬的发展现状[J].电镀与精饰,2009(01):13-17,22. |
| [7] | 吴慧敏,康健强,左正忠,梁国柱,赵国鹏.全硫酸盐体系三价铬电镀铬的研究[J].武汉大学学报(理学版),2004(02):187-191. |
| [8] | V.S. Protsenko;F.I. Danilov;V.O. Gordiienko;S.C. Kwon;M. Kim;J.Y. Lee .Electrodeposition of hard nanocrystalline chrome from aqueous sulfate trivalent chromium bath[J].Thin Solid Films,2011(1):380-383. |
| [9] | 安茂忠,屠振密.电镀Zn、Cu、Ni、Cr及其合金的研究进展[J].电子工艺技术,2001(01):5-9. |
| [10] | 张招贤,赵国鹏,胡耀红.三价铬电镀[J].电镀与涂饰,2005(12):50-53. |
| [11] | Baosong Li;An Lin;Xu Wu .Electrodeposition and characterization of Fe-Cr-P amorphous alloys from trivalent chromium sulfate electrolyte[J].Journal of Alloys and Compounds: An Interdisciplinary Journal of Materials Science and Solid-state Chemistry and Physics,2008(1/2):93-101. |
| [12] | BY. PROTSENKO;V. O. GORDIIENKO;F. I. DANILOV;S. C. KWON .Thick Chromium Electrodeposition from Trivalent Chromium Bath Containing Carbamide and Formic Acid[J].Metal finishing,2011(4):33-37. |
| [13] | V. S. Protsenko;V. O. Gordiienko;F. S. Danilov .Unusually high current efficiency of nanocrystalline Cr electrodeposition process from trivalent chromium bath[J].Surface Engineering,2011(9):690-692. |
| [14] | 梁奇峰,何江.三价铬电镀工艺初步研究[J].广东化工,2007(05):29-31. |
| [15] | 崔廷昌,张素兰.三价铬电镀[J].电镀与环保,2008(03):41-42. |
| [16] | 周智鹏,胡耀红,陈力格,赵国鹏,甘振杰.硫酸盐三价铬镀铬工艺中杂质的影响及去除[J].电镀与涂饰,2008(05):11-13. |
| [17] | 李广志,殷恒波,李海霞.硫酸铬（Ⅲ）生产工艺开发及在电镀中应用研究[J].江苏环境科技,2007(z2):11-14. |
| [18] | 郑瑞庭.镀铬阳极选用[J].电镀与涂饰,2004(03):51-52. |
| [19] | 毛祖国,管勇,丁运虎,何杰.氯化物体系三价铬电镀工艺研究[J].制造技术与机床,2008(04):87-91. |
| [20] | DEVILLIERS D;TINH THI M T;MAHE E .Cr (Ⅲ) oxidation with lead dioxide-based anodes[J].Electrochimica Acta,2003,48(28):4301-4309. |
| [21] | Ivanov I.;Stefanov Y. .Insoluble anodes used in hydrometallurgy Part I. Corrosion resistance of lead and lead alloy anodes[J].Hydrometallurgy,2000(2):109-124. |
| [22] | Ivanov I.;Stefanov Y. .Insoluble anodes used in hydrometallurgy Part II. Anodic behaviour of lead and lead-alloy anodes[J].Hydrometallurgy,2000(2):125-139. |
| [23] | 胡耀红,陈力格,刘建平.三价铬镀铬工艺及其新型阳极的初步研究[J].电镀与涂饰,2004(02):19-21. |
| [24] | Y. B. Song;D. -T. Chin .Current efficiency and polarization behavior of trivalent chromium electrodeposition process[J].Electrochimica Acta,2002(4):349-356. |
| [25] | Li BS;Lin A;Gan FX .Preparation and characterization of Cr-P coatings by electrodeposition from trivalent chromium electrolytes using malonic acid as complex[J].Surface & Coatings Technology,2006(6):2578-2586. |
| [26] | 邹忠,李劼,丁凤其,张文根,肖劲,叶绍龙,刘业翔.稀土Eu掺杂对金属氧化物涂层阳极电催化性能的影响[J].中国有色金属学报,2001(01):91-94. |
| [27] | S.Nijjer;J.Thonstad;G.M.Haarberg .Cyclic and linear voltammetry on Ti/IrO_2-Ta_2O_5-MnO_x electrodes in sulfuric acid containing Mn~(2+) ions[J].Electrochimica Acta,2001(23):3503-3508. |
| [28] | AROMAA J;FORSEN O .Evaluation of the electrochemical activity of a Ti-RuO2-TiO2 permanent anode[J].Electrochimica Acta,2006,51(27):6104-6110. |
| [29] | YE Z G;MENG H M;SUN D B .New degradation mechanism of Ti/IrO2 +MnO2 anode for oxygen evolution in 0.5M H2SO4 solution[J].Electrochimica Acta,2008,53(18):5639-5643. |
| [30] | Ye ZG;Meng HM;Sun DB .Electrochemical impedance spectroscopic (EIS) investigation of the oxygen evolution reaction mechanism of Ti/IrO_2+MnO_2 electrodes in 0.5 m H_2SO_4 solution[J].Journal of Electroanalytical Chemistry: An International Journal Devoted to All Aspects of Electrode Kinetics, Interfacial Structure, Properties of Electrolytes, Colloid and Biological Electrochemistry,2008(1):49-54. |
| [31] | HU J M;MENG H M;ZHANG J Q .Degradation mechanism of long service life Ti/IrO2-Ta2O5 oxide anodes in sulphuric acid[J].Corrosion Science,2002,44(08):1655-1668. |
| [32] | Panic VV;Jovanovic VM;Terzic SI;Barsoum MW;Jovic VD;Dekanski AB .The properties of electroactive ruthenium oxide coatings supported by titanium-based ternary carbides[J].Surface & Coatings Technology,2007(2):319-324. |
| [33] | 经志宏;李明杰 .在三价铬盐水溶液中电沉积铬工艺新型阳极材料的研究(Ⅱ)[J].延边大学学报（自然科学版）,1994,20(04):34-38. |
| [34] | 胡耀红,陈力格,赵国鹏,刘建平,洪榕.三价铬镀铬阳极的研究[J].材料保护,2006(04):26-28,31. |
| [35] | CHANG H;JOHNSON D C .Electrocatalysis of anodic oxygentransfer reactions:chronoamperometric and voltammetric studies of the nucleation and electrodeposition of β3-lead dioxide at a rotated gold disk electrode in acidic media[J].Journal of The Electrochemical Society,1989,136(01):17-22. |
| [36] | CHANG H;JOHNSON D C .Electrocatalysis of anodic oxygentransfer reactions:ultrathin films of lead oxide on solid electrodes[J].Journal of The Electrochemical Society,1990,137(10):3108-3113. |
| [37] | YEO I H;LEE Y S;JOHNSON D C .Growth of lead dioxide on a gold electrode in the presence of foreign ions[J].Electrochimica Acta,1992,37(10):1811-1815. |
| [38] | 刘丽,毛英杰,陈志红.钛合金在不同pH值人工唾液中耐腐蚀性能的研究[J].中国生物医学工程学报,2006(02):166-169. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%