研究了蛇纹石对磁铁矿和赤铁矿2种不同矿粉球团的生球质量、抗压强度和冶金性能的影响。结果表明：配蛇纹石后赤铁矿和磁铁矿球团的生球质量都得到改善。配蛇纹石后磁铁矿和赤铁矿球团预热强度都下降，在相同温度和蛇纹石质量分数下，赤铁矿球团预热强度比磁铁矿球团低50～100 N／个，在焙烧温度小于1280℃时，随着蛇纹石质量分数的增加，磁铁矿和赤铁矿球团抗压强度都下降，但在1300℃的温度下，配蛇纹石的球团抗压强度比基准期球团抗压强度高。配蛇纹石后磁铁矿和赤铁矿球团还原膨胀率都下降。蛇纹石质量分数为1．5％时，球团矿还原度相对高。
Effects of serpentine on green pellet quality,compression strength and metallurgical properties of pellet produced by magnetite and hematite iron ore concentrate are studied.The results show that,green pellet quality of both magnetite and hematite pellet is improved by addition of serpentine.The compression strength of preheated pel-let decreases after adding serpentine ,further the compression strength of hematite preheated pellet is lower than that of magnetite preheated pellet 50-100 N/P under the same preheating temperature and serpentine ratio.While fir-ing temperature is below 1 280 ℃,the compression strength of both magnetite and hematite pellet decreases with the increase of serpentine ratio.However the compression strength of pellet with serpentine is higher than pellet without serpentine when firing under 1 300 ℃.Serpentine will cause the decrease of reduction swelling index for magnetite and hematite pellet,and the reduction index is relatively higher when serpentine ratio is 1.5%.
参考文献
| [1] | 刘文旺,李明,青格勒,黄文斌,田伟杰,骆振勇.首钢京唐高镁球团工业试验[J].烧结球团,2012(05):36-39. |
| [2] | 谢路奔 .含镁球团焙烧固结强化及其机理研究[D].中南大学,2012. |
| [3] | 李圣辉,陈铁军,张一敏,赵杰.含镁添加剂用于铁矿球团的试验研究[J].烧结球团,2011(01):33-37,46. |
| [4] | 青格勒,吴铿,屈俊杰,刘文旺,田筠清,王梦.不同含镁添加剂对球团矿工艺参数及质量的影响[J].钢铁,2013(07):17-22. |
| [5] | 周明顺,沈峰满,翟立委,刘杰,张辉.MgO添加方式对改善球团矿冶金性能的影响[J].钢铁,2012(04):14-18. |
| [6] | 张永明,贾彦忠.熔剂性含MgO球团矿特点及生产实践[C].中国金属学会2004年全国炼铁生产技术暨炼铁年会论文集,2004:255-259. |
| [7] | 周国凡,杨福.添加MgO对球团矿成球性能及强度的影响[J].钢铁研究,2009(02):10-12. |
| [8] | 宋招权.MgO对球团矿质量的影响[J].烧结球团,2001(06):22-24. |
| [9] | 李学军,王丽娟,鲁安怀,王长秋.天然蛇纹石活性机理初探[J].岩石矿物学杂志,2003(04):386-390. |
| [10] | 王景峰,周莹莹,胡宏,张勇.蛇纹石加工新工艺基础研究[J].化工矿物与加工,2013(07):8-11. |
| [11] | 胡宾生,熊飞武.蛇纹石种类和粒度对烧结过程的影响[J].烧结球团,2010(05):23-26. |
| [12] | 熊飞武,胡宾生,贵永亮.蛇纹石对唐钢烧结过程的影响[J].河北理工大学学报（自然科学版）,2011(01):32-36. |
| [13] | 傅菊英;朱德庆.铁矿氧化球团基本原理、工艺及设备[M].长沙:中南大学出版社,2005 |
- 下载量()
- 访问量()
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%