讨论了基于柔性 PI 基底上的底栅型 TFT 器件工艺,通过工艺优化解决了双层结构干刻速率不同造成的下切角形状。本文 TFT 器件是基于氧化物 IGZO 为有源层,栅绝缘层采用 Si3 N4/SiO2双层结构,采用两次补偿曝光、干刻方式消除干刻引入的下切角形状,有效解决了薄膜沉积引入的断线风险。实验结果表明,经过 SEM 断面观察,干刻后双层结构taper 角度适合 TFT 器件后续沉膜条件,柔性基底上制作的 TFT 器件迁移率达到14．8 cm2/(V.s),阈值电压 V th 约0.5 V,亚域值摆幅 SS 约0．5 V/decade,TFT 器件的开关比 I on/I of ＞106。通过此方法制作出的器件性能良好,满足LCD、OLED 或电子纸的驱动要求。
Bottom-gate structure TFT device technology on flexible PI substrate was discussed in the paper.Undercut shape of the double layer caused by the different dry etching rate was solved by the improvement of technics.The TFT device was based on IGZO as active layer,and Si3 N4/SiO2 double layer structure was employed as gate insulator,undercut shape introduced thin film deposition break risk was effectively solved using two times of exposure compensation.The experimental results show that,the taper angle of double-layer structure after dry etching which was observed using SEM was suitable for following film deposition of TFT devices.The mobility of TFT on flexible PI substrate reaches 14.8 cm2/(V.s),threshold voltage of V th is about 0.5 V,subthreshold swing (SS)is about 0.5 V/decade,and ratio of I on/I of is upper 10 6 .TFT device performance by this method is good,and meets the driving requirements of LCD,OLED or electronic paper.
参考文献
| [1] | Wu C C,Theiss S D,Gu G,et al.Integration of organic LED′s and Amorphous Si TFT′s onto flexible and light-weight metal foil substrates [J].IEEE ELECTRON DEVICE LETTERS,1997,18(12):609-612.,1997. |
| [2] | Zhou L S,Wanga A,Wu S C,et al.All-organic active matrix flexible display [J].Applied Physics Letters,2006, 88(8):083502.,2006. |
| [3] | Jeong J K,Jin D U,Shin H S,et al.Flexible full-color AMOLED on ultrathin metal foil [J].Ieee Electron Device Letters,2007,28(5):389-391.,2007. |
| [4] | Plichta A,Weber A.Ultra-thin flexible glass substrates [C].Proc.Mater.Res.Soc.Symp.,2003,769:H9.1-H9.10.,2003. |
| [5] | Cheng I C,Kattamis A,Wagner S.Stress control for overlay registration in a-Si:H TFTs on flexible organicpoly-mer-foil substrates [J].J.Soc.Inf.Display,2005,13(7):563-568.,2005. |
| [6] | Choi M H,Kim B S,Jang J.High-performance flexible TFT circuits using TIPS pentacene and polymer Blend on Plastic [J].Ieee Electron Device Letters,2012,33(1):1571-1573.,2012. |
| [7] | Lim W,Jang J H,Kim S H,et al.High performance indium gallium zinc oxide thin film transistors fabricated on polyethylene terephthalate substrates [J].Applied Physics Letters,2008,93:082102.,2008. |
| [8] | Chen C,Abe K,Kumomi H,et al.Density of states of a-InGaZnO from temperature-dependent field-effect studies [J].Ieee Transactions On Electron Devices,2009,56(6):1177-1183.,2009. |
| [9] | Hsu H H,Chang C Y,Cheng C H,et al.Fully room-temperature IGZO thin film transistors adopting stacked gate dielectrics on flexible polycarbonate substrate [J].Solid-State Electronics,2013,89:194-197.,2013. |
| [10] | Liu C,Wei M,Yang F,et al.Effects of electrode materials on the performances of IGZO-based thin film transistor [J].Chinese J ournal of Luminescence,2014,35(11):1365-1369.,2014. |
| [11] | 贾田颖,詹润泽,董承远.基于a-IGZO TFT的AMOLED像素电路稳定性的仿真研究[J].发光学报,2013(09):1240-1244. |
- 下载量()
- 访问量()
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%