以白刚玉、℃-Al2O3粉、锆英石和氧化铬为主要原料,在200 MPa油压机上压制成50 mm×50 mm×5 mm的试样,在空气气氛中于1 500 ℃煅烧5 h,制得Al2O3-Cr2O3-ZrO2试样.将0.6 g变形温度约为1 120℃的云贵煤灰平铺在Al2O3-Cr2O3-ZrO2试样上,然后放入马弗炉中分别在空气和弱还原性气氛下于1 250℃煅烧5 h,随炉冷却后观察煤灰在Al2O3-Cr2O3-ZrO2试样上的结渣情况,并进行SEM及EDS分析.结果表明:在弱还原气氛条件下,煤灰在Al2O3-Cr2O3-ZrO2上的结渣非常致密;而在空气气氛条件下,煤灰与Al2O3-Cr2O3-ZrO2材料间的粘接比较疏松,两者间没有明显的相互渗透.
参考文献
| [1] | Chen D L;Liu L;Zheng C G .Quasi-constant temperature combustion for improving overall performance of a coal-fired boiler[J].Combustion and Flame,2003,134(1-2):81-92. |
| [2] | Chen F C;Bernard B A;Wiilianm E L .Prediction of the effect of additives an slag resistance of Al2O3-SiO2-C bond phase in air[J].Calphad-computer coupling of phase diagrams and thermochemistry,2003,27(01):115-125. |
| [3] | S. Vargas;F.J. Frandsen;K. Dam-Johansen .Rheological properties of high-temperature melts of coal ashes and other silicates[J].Progress in energy and combustion science,2001(3):237-429. |
| [4] | Quanhai Wang;Jianrong Qiu;Yinghui Liu;Chuguang Zheng .Effect of atmosphere and temperature on the speciation of mineral in coal combustion[J].Fuel Processing Technology,2004(12):1431-1441. |
| [5] | Stanislav V. Vassilev;Kunihiro Kitano;Shohei Takeda;Takashi Tsurue .Influence of mineral and chemical composition of coal ashes on their fusibility[J].Fuel Processing Technology,1995(1):27-51. |
| [6] | 陈鸿伟,李永华,梁化忠.锅炉高温腐蚀实验研究[J].中国电机工程学报,2003(01):167-170. |
| [7] | 白进,李文,李保庆.高温弱还原气氛下煤中矿物质变化的研究[J].燃料化学学报,2006(03):292-297. |
| [8] | 陈吟颖,阎维平,石惠芳.330MW燃煤机组锅炉炉膛结渣性能的研究[J].中国电机工程学报,2005(11):79-84. |
| [9] | 郑伟栋,王庆祥.我国高炉用耐火材料的进展[J].耐火材料,2000(03):175-177. |
| [10] | 胡水,于仁红,蒋明学.刚玉质耐火材料高温耐冲蚀磨损性能的研究[J].耐火材料,2005(06):415-418. |
| [11] | Korgul P;Wolson D R;Lee W E .Mierostructural analysis of corroded alumina-spinel castable refractories[J].Journal of the European Ceramic Society,1997,17(01):77-84. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%