以Al2O3-13%TiO2粉末和ZrO2粉末为原料,采用等离子喷涂法在20钢基体上制备了40%ZrO2-Al2O3-13%TiO2陶瓷涂层,观察了涂层的微观形貌,在室温干滑动摩擦条件下对涂层和20钢基体进行摩擦磨损实验,对比了二者的摩擦系数和磨损形貌,并分析了磨损机理.结果表明:涂层内部结合紧密,且以机械结合为主;涂层的摩擦磨损性能优于20钢基体,其磨损机理为微观断裂引起的剥落磨损.
参考文献
| [1] | KEAR B H;SAKANGI P K;JAIN M.Thermal Sprayed Nanostructured WC/Co Hard Coatings[J].Journal of Thermal Spray Technology,2000(09):399-406. |
| [2] | YANG Yuan-zheng;ZHU You-lan;LIU Zheng-yi et al.Laser Remelting of Plasma Sprayed Al2 O3 Ceramic Coatings and Subsequent Wear Resistance[J].Materials Science and Engineering,2000,A291:168-172. |
| [3] | Yang Yuanzheng;Liu Zhiguo;Liu Zhengyi;Chuang Yuzhi .Interfacial phenomena in the plasma spraying Al{sub}2O{sub}3 + 13 wt.% TiO{sub}2 ceramic coating[J].Thin Solid Films: An International Journal on the Science and Technology of Thin and Thick Films,2001(1/2):208-212. |
| [4] | Dongsheng Wang;Zongjun Tian;Lida Shen;Zhidong Liu;Yinhui Huang .Influences Of Laser Remelting On Microstructure Of Nanostructured Al_2o_3-13 Wt.% Tio_2 Coatings Fabricated By Plasma Spraying[J].Applied Surface Science: A Journal Devoted to the Properties of Interfaces in Relation to the Synthesis and Behaviour of Materials,2009(8):4606-4610. |
| [5] | WANG Y;LI C G;TIAN W et al.Laser Surface Remelting of Plasma Sprayed Nanostructured Al2O313wt.%TiO2 Coatings on Titanium Alloy[J].Applied Surface Science,2009,255:8603-8610. |
| [6] | DEJANG N;WATCHARAPASORN A;WIROJUPATUMP S et al.Fabrication and Properties of Plasmasprayed Al2O3/TiO2 Composite Coatings:A Roleof Nano-sized TiP2 Addition[J].Surface and Coatings Technology,2010,204:1651-1657. |
| [7] | Yin Zhi-jian;Tap Shun-yan;Zhou Xia-ming et al.Tribological Properties of Plasma Sprayed Al/Al2O3 Composite Coatings[J].WEAR,2007,263:1430-1437. |
| [8] | LIN X H;ZENG Y;DING C X et al.Tribological Behaviour of Nano-structured Al2 O3-3wt.% TiP2 Coating Against Steel in Dry Sliding[J].Tribology Letters,2004,17:19-26. |
| [9] | 马岳;段祝平 .表面等离子喷涂材料研究的现状及发展[J].表面技术,1999,28(04):1-4. |
| [10] | F. Wang;L.Wang;G. Liu .MECHANISM OF TRANSIENT THERMAL CYCLE FAILURE IN ZrO_2/NiCrAl FUNCTIONALLY GRADED THERMAL BARRIER COATINGS[J].Surface Engineering,2001(1):35-37. |
| [11] | ZHAO Xiao-qin;AN Yu-long;CHEN Jian-min et al.Properties of Al2O3-40wt.% ZrO2 Composite Coatings from Ultra-fine Feedstocks by Atmospheric Plasmas Spraying[J].WEAR,2008,265:1642-1648. |
| [12] | Liang, B;Zhang, G;Liao, HL;Coddet, C;Ding, CX .Friction and wear behavior of ZrO2-Al2O3 composite coatings deposited by air plasma spraying: Correlation with physical and mechanical properties[J].Surface & Coatings Technology,2009(20/21):3235-3242. |
| [13] | 濮春欢,徐滨士,王海斗,朴钟宇.干摩擦条件下3 Cr13涂层的加速磨损机理研究[J].摩擦学学报,2009(04):368-373. |
| [14] | J.K.M.F. Daguano;C. Santos;R.C. Souza .Properties of ZrO_2-Al_2O_3 composite as a function of isothermal holding time[J].International Journal of Refractory Metals & Hard Materials,2007(5/6):374-379. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%