采用TEM,SEM和XPS等测试分析方法,研究了微量Cr的添加对铜合金在二氧化硫环境中耐蚀性的影响.结果表明:微量Cr的加入提高了合金的耐蚀性,随着添加量的增多,合金的耐蚀性进一步提高;另一方面,由于合金中低含量的Cr不能在试样表面独立成膜,耐蚀性的提高很大程度上依赖于致密腐蚀产物层对含Cr层的保护作用,所以微量Cr的加入对合金耐蚀性的改善是轻微的.同时,Cr的分布不均对合金的耐蚀性有一定的破坏作用.
参考文献
| [1] | LUO C P .Morphology and crystallography of Cr precipitates in a Cu-O.33Cr alloy[J].Acta Metallurgica Et Materialia,1994,42(06):1923-1933. |
| [2] | FUJⅡ T;NAKAZAWA H;KATO M et al.Crystallography and morphology of nanosized Cr particles in a Cu-O.2Cr alloy[J].Acta Materials,2000,48:1033-1045. |
| [3] | Xie M.;Lu XY.;Shi A.;Den ZM.;Jang H.;Zheng FQ.;Liu JL. .Investigation on the Cu-Cr-RE alloys by rapid solidification[J].Materials Science & Engineering, A. Structural Materials: Properties, Misrostructure and Processing,2001(0):529-533. |
| [4] | PETER D;LEYGRAF C .Vibrational spectroscopy and XPS for atmospheric corrosion studies on copper[J].Journal of the Electrochemical Society,1990,137(10):3163-3169. |
| [5] | CHAWLA S K;PAYER J H .The early stage of atmospheric corrosion of copper by sulfur dioxide EJ3[J].Journal of the Electrochemical Society,1990,137(01):60-64. |
| [6] | TIDBLAD;GRAEDE T E .Gildes model studies of aqueous chemistry.Ⅲ.Initial SO2-induced atmospheric corrosion of copper[J].Corrosion Science,1996,38(12):2201-2223. |
| [7] | Jun Itoh;Takeshi Sasaki;Toshiaki Ohtsuka;Masatoshi Osawa .Surface layers formed initially on copper in air containing water vapor and SO_2 as determined by IR-RAS and 2D-IR[J].Journal of Electroanalytical Chemistry: An International Journal Devoted to All Aspects of Electrode Kinetics, Interfacial Structure, Properties of Electrolytes, Colloid and Biological Electrochemistry,1999(1/2):256-264. |
| [8] | 杨红旺 .铸造合金组织与性能的研究[D].西安:西安理工大学,2000. |
| [9] | 杨德钧;沈卓身.金属腐蚀学[M].北京:冶金工业出版社,1999 |
| [10] | Pardo A.;Merino MC.;Lopez MD.;Vazquez M.;Agudo P.;Otero E. .Influence of Cr addition on the corrosion resistance and magnetic properties of amorphous Fe73.5Si13.5B9Nb3Cu1 in simulated industrial environments[J].Journal of Non-Crystalline Solids: A Journal Devoted to Oxide, Halide, Chalcogenide and Metallic Glasses, Amorphous Semiconductors, Non-Crystalline Films, Glass-Ceramics and Glassy Composites,2001(1/3):421-427. |
| [11] | SCULLY J C.The fundament of corrosion[M].New York:pergaman Press,1975 |
| [12] | 宋诗哲,唐子龙.Al-Mg合金在不同pH值的NaCl溶液中的腐蚀行为[J].腐蚀科学与防护技术,1995(03):218. |
| [13] | SHANLEY C W;HUMMEL R E;VERINK E D .Differential reflectometry of corrosion products of copper[J].Corrosion,1980,20:481-487. |
| [14] | 刘建华,高月敏,章向前,钱建明,姚辉军.Cu-Cr合金在3.5%NaCl溶液中腐蚀的研究[J].上海有色金属,2003(04):149-151. |
| [15] | 傅艳,牛焱,吴维.Cu-Cr合金在H2-H2S混合气中的腐蚀行为[J].中国有色金属学报,2001(04):562-566. |
| [16] | 王继东,徐静英.Cu-Cr合金在3.5%NaCl+NH3溶液中的腐蚀行为[J].物理测试,2004(06):5-7. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%