采用扫描电镜(SEM)和金相显微镜(OM)组织观察以及能谱(EDS)分析等手段研究了固溶处理温度对第三代镍基单晶高温合金DD10显微组织、枝晶偏析和组织稳定性的影响.结果表明:合金经1290℃/6h固溶后共晶基本消除,1330℃/6h固溶时出现少量微孔,1340℃/6h时则出现初熔.合金经1320℃和1330℃固溶处理后,枝晶偏析程度明显改善.1095℃组织稳定性研究表明:合金经1330℃固溶处理后的由于枝晶偏析程度较小,析出的TCP相数量显著减少,合金的组织稳定性较好.此外,固溶温度对γ'相形貌、体积分数和尺寸的影响不大.
参考文献
[1] | 胡壮麒,刘丽荣,金涛,孙晓峰.镍基单晶高温合金的发展[J].航空发动机,2005(03):1-7. |
[2] | 陈荣章.单晶高温合金发展现状[J].材料工程,1995(08):3. |
[3] | REED R C.The superalloys:Fundamentals and applications[M].Cambridge:Cambridge University Press,2006 |
[4] | J. Rusing;N. Wanderka;U. Czubayko .Rhenium distribution in the matrix and near the particle-matrix interface in a model Ni-Al-Ta-Re superalloy[J].Scripta materialia,2002(3):235-240. |
[5] | GIAMEI A;ANTON D .Rhenium additions to a Ni-base superalloy:Effects on microstrueture[J].Metallurgical and Materials Transactions,1985,16A(11):1997-2005. |
[6] | C. M. F. RAE;R. C. REED .THE PRECIPITATION OF TOPOLOGICALLY CLOSE-PACKED PHASES IN RHENIUM-CONTAINING SUPERALLOYS[J].Acta materialia,2001(19):4113-4125. |
[7] | ERICKSON G L.The development and application of CMSX-10[A].Champion,PA:TMS,1996:35-44. |
[8] | G. E. Fuchs .Solution heat treatment response of a third generation single crystal Ni-base superalloy[J].Materials Science & Engineering, A. Structural Materials: Properties, Misrostructure and Processing,2001(1/2):52-60. |
[9] | G.E. Fuchs .Improvement of Creep Strength of a Third Generation, Single-Crystal Ni-Base Superalloy by Solution Heat Treatment[J].Journal of Materials Engineering and Performance,2002(1):19-25. |
[10] | B. C. Wilson;J. A. Hickman;G. E. Fuchs .The Effect of Solution Heat Treatment on a Single-Crystal Ni-Based Superalloy[J].JOM,2003(3):35-40. |
[11] | 肖旋,郭建亭,于海朋.固溶处理冷却速度对DZ417G合金组织性能的影响[J].材料研究学报,2006(05):533-537. |
[12] | MINAMINO Y;JUNG S B;YAMANE T et al.Diffusion of cobalt,chromium,and titanium in Ni3Al[J].Metallurgical and Materials Transactions,1992,23A(10):2783-2790. |
[13] | Q. FENG;L.J. CARROLL;T.M. POLLOCK .Solidification Segregation in Ruthenium-Containing Nickel-Base Superalloys[J].Metallurgical and Materials Transactions, A. Physical Metallurgy and Materials Science,2006(6):1949-1962. |
[14] | 陈晶阳 .Ru和Cr对镍基单晶高温合金组织和蠕变持久性能的影响[D].北京:北京科技大学,2011. |
[15] | A.C. YEH;S. TIN .Effects of Ru on the High-Temperature Phase Stability of Ni-Base Single-Crystal Superalloys[J].Metallurgical and Materials Transactions, A. Physical Metallurgy and Materials Science,2006(9):2621-2631. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分:
-
10%
-
20%
-
30%
-
40%
-
50%