采用SEM、XPS等测试方法,研究了铜铬合金在二氧化硫环境中的腐蚀情况.结果表明,铜铬合金的耐蚀性较纯铜的耐蚀性有一定程度的提高;XPS分析显示,当合金试样在腐蚀环境中的增重量不再随时间发生变化时,合金表面的腐蚀产物以铜的硫酸盐为主,腐蚀产物中没有发现含Cr相的存在;另一方面,由于合金中低含量的Cr不能在试样表面独立成膜,所以合金耐蚀性的提高很大程度上依赖于致密腐蚀产物层对合金基体的保护作用.
参考文献
[1] | Akira Tahara;Tadashi Shinohara .Influence of the alloy element on corrosion morphology of the low alloy steels exposed to the atmospheric environments[J].Corrosion Science,2005,47:2089-2099. |
[2] | Y. F. Cheng;J. Bullerwell;F. R. Steward .Electrochemical investigation of the corrosion behavior of chromium-modified carbon steels in water[J].Electrochimica Acta,2003(11):1521-1530. |
[3] | Fujiwara M;Takanashi K;Satou M;Hasegawa A;Abe K;Kakiuchi K;Furuya T .Influence of Cr, Ti concentrations on oxidation and corrosion resistance of V-Cr-Ti type alloys[J].Journal of Nuclear Materials: Materials Aspects of Fission and Fusion,2004(0):452-456. |
[4] | 刘建华,高月敏,章向前,钱建明,姚辉军.Cu-Cr合金在3.5%NaCl溶液中腐蚀的研究[J].上海有色金属,2003(04):149-151. |
[5] | 傅艳,牛焱,吴维.Cu-Cr合金在H2-H2S混合气中的腐蚀行为[J].中国有色金属学报,2001(04):562-566. |
[6] | 邵力,王久亮,高月敏,钱建明,姚辉军.Cu-Cr合金在NaOH溶液中腐蚀行为[J].物理测试,2003(03):32-34. |
[7] | Peter D;Leygraf C .Vibrational spectroscopy and XPS for atmospheric corrosion studies on copper[J].Journal of the Electrochemical Society,1990,137(10):3163-3169. |
[8] | 杨德钧;沈卓身.金属腐蚀学[M].北京:冶金工业出版社,1999:18. |
[9] | Pardo A.;Merino MC.;Lopez MD.;Vazquez M.;Agudo P.;Otero E. .Influence of Cr addition on the corrosion resistance and magnetic properties of amorphous Fe73.5Si13.5B9Nb3Cu1 in simulated industrial environments[J].Journal of Non-Crystalline Solids: A Journal Devoted to Oxide, Halide, Chalcogenide and Metallic Glasses, Amorphous Semiconductors, Non-Crystalline Films, Glass-Ceramics and Glassy Composites,2001(1/3):421-427. |
[10] | Scully J C.The fundament of corrosion[M].Pergamon Press,1975:32-48. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分:
-
10%
-
20%
-
30%
-
40%
-
50%