提出了一种以镁合阳极极化曲线来判断微弧氧化起弧难易的新方法。在不同的电解液中，测试了镁合金的阳极极化曲线及微弧氧化的起弧特性。结果表明，起弧电压首先与其在对应电解液中进行阳极极化时形成的钝化膜的稳定性有关：膜层越稳定，即阳极极化曲线上钝化区宽度越宽，则在相应的电解液中微弧氧化起弧电压越低；当钝化区间宽度相近时，则在钝化区间后期极化电流越小，起弧电压越低。
A new method on predicting arc-initiating of micro-arc oxidation on magnesium alloy by anodic polarization curve was proposed. Anodic polarization behavior and discharge characteristic were tested in different solutions. The results show that arcing voltage is much dependent on the stability of passivating films formed during anodic polarization process. The arcing voltage is higher with a larger width of passivation region of the polarization curve. When the stability of passivating films is at about the same level, the arcing voltage becomes lower in the solution possessing a smaller polarization current at the later section of passivation curves.
参考文献
| [1] | E. Aghion;B. Bronfin;D. Eliezer .The role of the magnesium industry in protecting the environment[J].Journal of Materials Processing Technology,2001(3):381-385. |
| [2] | J.E. Gray;B. Luan .Protective coatings on magnesium and its alloys-a critical review[J].Journal of Alloys and Compounds: An Interdisciplinary Journal of Materials Science and Solid-state Chemistry and Physics,2002(1/2):88-113. |
| [3] | 郭锋,刘瑞霞,李鹏飞,刘亮.电解液中的稀土对AZ91D镁合金微弧氧化陶瓷层的影响[J].材料热处理学报,2011(02):134-138. |
| [4] | 吴汉华,于凤荣,李俊杰,吕宪义,金曾孙.铝合金微弧氧化陶瓷膜形成过程中的特性研究[J].无机材料学报,2004(03):617-622. |
| [5] | Wang C Z;Zhang D;Jiang Y F .Growth process and wear resistance for ceramic coatings formed on A1-Cu-Mg alloy by micro-arc oxidation[J].Applied Surface Science,2006,253(02):674-678. |
| [6] | Xin SG;Song LX;Zhao RG;Hu XF .Influence of cathodic current on composition, structure and properties of Al2O3 coatings on aluminum alloy prepared by micro-arc oxidation process[J].Thin Solid Films: An International Journal on the Science and Technology of Thin and Thick Films,2006(1):326-332. |
| [7] | P.I. Butyagin;Ye.V. Khokhryakov;A.I. Mamaev .Microplasma systems for creating coatings on aluminium alloys[J].Materials Letters,2003(11):1748-1751. |
| [8] | Di Wu;Xiangdong Liu;Kai Lu;Yaping Zhang;Huan Wang .Influence of C_3H_8O_3 in the electrolyte on characteristics and corrosion resistance of the microarc oxidation coatings formed on AZ91D magnesium alloy surface[J].Applied Surface Science: A Journal Devoted to the Properties of Interfaces in Relation to the Synthesis and Behaviour of Materials,2009(16):7115-7120. |
| [9] | Nie S;Emory S R .Probing single molecules and single nanoparticles by surface-enhanced Raman scattering[J].Science,1997,275(5303):1102-1106. |
| [10] | 薛文斌,邓志威,张通和,陈如意,李永良.铸造镁合金微弧氧化机理[J].稀有金属材料与工程,1999(06):353-356. |
| [11] | 查全性.电极过程动力学导论[M].北京:科学出版社,2004:326-329. |
| [12] | Ikonopisov S;Girginov A;Machkova M .Post-breakdown anodization of aluminium[J].Eleetroehimica Acta,1997,22(11):1283-1286. |
| [13] | Ikonopisov S .Theory of electrical breakdown during formation of barrier anodic films[J].Electrochimica Acta,1997,22(10):1077-1082. |
| [14] | 吴辉煌.电化学[M].北京:化学工业出版社,2004:214. |
| [15] | 杨巍,蒋百灵,时惠英,鲜林云,李均明.预制备膜特性对铝合金微弧氧化膜层形成过程的影响[J].材料热处理学报,2010(03):116-120. |
| [16] | 杨巍,蒋百灵,鲜林云.溶质离子在镁合金微弧氧化膜形成过程中的作用[J].材料热处理学报,2009(01):157-160. |
| [17] | 王晓波,田修波,巩春志,杨士勤.镁合金微弧氧化Na2CO3诱导析气反应及结构调制[J].无机材料学报,2011(07):721-725. |
| [18] | 张鉴清.电化学测试技术[M].北京:化学工业出版社,2010:226-229. |
- 下载量()
- 访问量()
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%