用热重分析法研究了低温下不同粒度氧化铁的氢还原动力学,得出在同一温度下,铁矿粉粒度从107.5μm降到2.μm后,由于粉体的表面积大幅度增加,提高了粉气接触面积,从而使得化学反应的速度提高了8倍左右,还原反应的表观活化能从78.3 kJ/mol降低到36.9 kJ/mol;当反应速度相同时,粒度6.5μm的粉体的反应温度比107.5μm的降低了 80℃左右.同时,通过理论推导和实验结果表明,当反应扩散层厚度相同时,铁矿粉粒度越小,反应扩散层厚度越薄,其还原率越高.
参考文献
| [1] | Fruehan R J;Li Y;Brabie L .Final Stage of Reduction of Iron Ores by Hydrogen[J].Scandinavian Journal of Metallurgy,2005,34:205. |
| [2] | El-geassy A A;Nasr M I .Influence of Original Structure on the Kinetics and Mechanisms of Carbon Monoxide Reduction of Hematite Compacts[J].ISIJ International,1990,30(06):417. |
| [3] | Sujoy K Dutta;Ahindra Ghosh .Kinetics of Gaseous Reduc-tion of Iron Ore Fines[J].ISIJ International,1993,33(11):1168. |
| [4] | Parviz Pourghahramani .Reduction Kinetics of Mechanically Aetivated Hematite Concentrate With Hydrogen Gas Using Nonisothermal Methods[J].Thermochimica Acta,2007,454(02):69. |
| [5] | Pineau A;Kanari N;Gaballah I .Kinetics of reduction of iron oxides by H-2 - Part I: Low temperature reduction of hematite[J].Thermochimica Acta: An International Journal Concerned with the Broader Aspects of Thermochemistry and Its Applications to Chemical Problems,2006(1):89-100. |
| [6] | Unal A;Bradshaw A V .Rate Processes and Structural Chan-ges in Gaseous Reduction of Hematite Particles to Magnetit[J].Metallurgical and Materials Transactions B:Process Metallurgy and Materials Processing Science,1983,14B(12):743. |
| [7] | Farren M;Matthew S P;Hayes P C .Reduction of Solid Wus-rite in H2/H2O/CO/CO2 Gas Mixtures[J].Metallurgical and Materials Transactions B:Process Metallurgy and Materials Processing Science,1990,21B(02):135. |
| [8] | R.A.D. Rodriguez;A.N. Conejo;E.B. Bedolla .Kinetics of Reduction of Fe_2O_3 Particles with H_2-CO Mixtures at Low Temperatures[J].Iron & Steelmaker,2003(1):25-33. |
| [9] | 赵沛,郭培民,张殿伟.低温非平衡条件下氧化铁还原顺序研究[J].钢铁,2006(08):12-15. |
| [10] | 赵沛;郭培民.纳米冶金技术的研究及前景[A].北京:冶金工业出版社,2005:677. |
| [11] | 赵沛,郭培民.利用粉体纳米晶化促进低温冶金反应的研究[J].钢铁,2005(06):6-9. |
| [12] | 赵沛,郭培民.低温还原钛铁矿生产高钛渣的新工艺[J].钢铁钒钛,2005(02):1-4. |
| [13] | 郭培民,张殿伟,赵沛.氧化铁还原率及金属化率的测量新方法[J].光谱学与光谱分析,2007(04):816-818. |
| [14] | 黄希祜.钢铁冶金原理[M].北京:冶金工业出版社,1990 |
| [15] | 华一新.冶金过程动力学导论[M].北京:冶金工业出版社,2004 |
| [16] | 刘建华,张家芸,周土平.CO及CO-H2气体还原铁氧化物反应表观活化能的评估[J].钢铁研究学报,2000(01):5-9. |
| [17] | 刘建华;张家芸;周土平 .氢气还原铁氧化物反应表观活化能的评估[J].钢铁研究学报,1999,11(06):9. |
| [18] | 赵沛,郭培民,张殿伟.机械力促进低温快速反应的研究[J].钢铁钒钛,2007(02):1-5. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%