采用溶胶-凝胶(sol-gel)自旋涂敷法在硅基氧化铝纳米有序孔膜版介质上(膜版孔径尺寸20～100nm,内生长金属纳米线作为底电极一部分)制备Pb(Zr0.53Ti0.47)O3(PZT)纳米结构铁电膜,并对其介电、铁电性能及微结构进行了表征.介电测量结果表明,厚度25nm的PZT铁电膜,其介电常数在低频区域(频率<104Hz)从860迅速下降到100,然后保持在100左右,直至测量频率升高到106Hz.低频区域的介电常数迅速下降是由空间电荷极化所致,它与薄膜和电极之间聚集的界面空间电荷密切相关,尤其是在薄膜与Au纳米线的弯曲界面处.介电损耗在4000Hz附近出现峰值,它来源于空间电荷的共振吸收效应.电滞回线测量结果表明,厚度为100nm的PZT铁电膜,其剩余极化强度为50μC/cm2,矫顽场强为500kV/cm.剖面透射电镜(TEM)像表明PZT纳米铁电膜与底电极(金属纳米线)直接相接触,它们之间的界面呈现一定程度的弯曲.在 PZT纳米铁电薄膜后退火处理后,发现部分Au金属纳米线顶端出现分枝展宽现象;而改用Pt纳米线后可有效抑制这种现象.为兼顾氧化铝纳米有序孔膜版内的金属纳米线有序分布及PZT纳米膜的结晶度,选择合适的退火温度是制备工艺中的关键因素.
参考文献
| [1] | Scott J F;Araujo C A .[J].Science,1989,246(4936):1400-1405. |
| [2] | International FRAM Roadmap[OL].http://public.itrs.net,1998-08-16. |
| [3] | S. Buhlmann;B. Dwir;J. Baborowski;P. Muralt .Size effect in mesoscopic epitaxial ferroelectric structures: Increase of piezoelectric response with decreasing feature size[J].Applied physics letters,2002(17):3195-3197. |
| [4] | Nagarajan V;Roytburd A;Stanishevsky A et al.[J].Nature Materials,2003,2(01):43-47. |
| [5] | J.-H. Li;L. Chen;V. Nagarajan;R. Ramesh;A. L. Roytburd .Finite element modeling of piezoresponse in nanostructured ferroelectric films[J].Applied physics letters,2004(14):2626-2628. |
| [6] | Okamura S;Yagi Y;Ando S et al.[J].Japanese Journal of Applied Physics,1996,35(12B):6579-6583. |
| [7] | Alexe M;Harnagea C;Hesse D .[J].Journal of Electroceramics,2004,12(1-2):69-88. |
| [8] | A. Stanishevsky;B. Nagaraj;J. Melngailis;R. Ramesh;L. Khriachtchev;E. McDaniel .Radiation damage and its recovery in focused ion beam fabricated ferroelectric capacitors[J].Journal of Applied Physics,2002(6):3275-3278. |
| [9] | Roelofs A.;Schneller I.;Szot K.;Waser R. .Piezoresponse force microscopy of lead-titanate nanograins possibly reaching the limit of ferroelectricity[J].Applied physics letters,2002(27):5231-5233. |
| [10] | Szafraniak I;Harnagea C;Scholz R et al.[J].Applied Physics Letters,2003,83(11):2211-2213. |
| [11] | Ahn S H;Jung W W;Choi S K .[J].Applied Physics Letters,2005,86(17):172901-1721-3. |
| [12] | Nonomura H;Nagata M;Fujisawa H et al.[J].Applied Physics Letters,2005,86(16):163106-1631-3. |
| [13] | Chik H;Xu JM .Nanometric superlattices: non-lithographic fabrication, materials, and prospects[J].Materials Science & Engineering, R. Reports: A Review Journal,2004(4):103-138. |
| [14] | Lei, Y;Chim, WK .Shape and size control of regularly arrayed nanodots fabricated using ultrathin alumina masks[J].Chemistry of Materials,2005(3):580-585. |
| [15] | Morrison F D;Luo Y;Szafraniak I et al.[J].Reviews on Advanced Materials Science,2003,4(02):114-122. |
| [16] | Sven Clemens;Theodor Schneller;Andre van der Hart;Frank Peter;Rainer Waser .Registered Deposition of Nanoscale Ferroelectric Grains by Template-Controlled Growth[J].Advanced Materials,2005(11):1357-1361. |
| [17] | Zhu X H;Evans P R;Byrne D et al.[J].Applied Physics Letters,2006,89(12):122913-1221-3. |
| [18] | 朱信华,朱健民.铁电纳米材料和纳米结构研究的进展[J].电子显微学报,2007(03):238-258. |
| [19] | Yadlovker D;Berger S .Controlled growth and nucleation of ferroelectric and dielectric single-crystal nano-rods inside nano-porous aluminum oxide[J].Sensors and Actuators, B. Chemical,2007(1):277-282. |
| [20] | Evans PR;Zhu XH;Baxter P;McMillen M;McPhillips J;Morrison FD;Scott JF;Pollard RJ;Bowman RM;Gregg JM .Toward self-assembled ferroelectric random access memories: Hard-wired switching capacitor arrays with almost Tb/in. (2) Densities[J].Nano letters,2007(5):1134-1137. |
| [21] | Atkinson R;Hendren W R;Wurtz G A .[J].Physical Review B:Condensed Matter,2006,73(23):235402-2351-8. |
| [22] | Saad M.M.;Baxter P.;Mcaneney J.;Lookman A.;Sinnamon L.J.;Evans P.;Schilling A.;Adams T.;Xinhua Zhu;Pollard R.J.;Bowman R.M.;Gregg J.M.;Jung D.J.;Morrison F.D.;Scott J.F. .Investigating the effects of reduced size on the properties of ferroelectrics[J].IEEE Transactions on Ultrasonics, Ferroelectrics, and Frequency Control,2006(12):2208-2225. |
| [23] | Barsoum M W.Fundamentals of Ceramics[M].New York:the McGraw-Hill Companies,Inc,1997:543. |
| [24] | Pandey S K;James A R;Prakash C et al.[J].Materials Science and Engineering B,2004,112(01):96-100. |
| [25] | 朱信华,朱健民,刘治国,闵乃本.BaTiO3铁电纳米膜制备及物性和微结构表征[J].电子显微学报,2009(02):180-185. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%