Kaifeng ZHANG
,
Wenbo HAN
,
Wei WU
,
Guofeng WANG
,
Dezhong WU
材料科学技术（英文）
The research on numerical simulation for combinative process of SPF/DB is carried out in this paper. The contacting problem of sheets is analyzed by using the penalty method. In order to solve the contact problem of different parts of the sheet, a new algorithm for contacting judgment is proposed. According to the relation of the distance vector and the vector of contacting element area, and the condition of contact, it can be judged whether or not a node on the slave surface and the corresponding master surface are in the state of SPF/DB. The Mindlin shell element is employed to simulate SPF/DB process of an asymmetry double-cell cup of Ti-6Al-4V to examine the efficiency of the new algorithm using ARVIP-3D. The results of the numerical simulation are in good agreement with experimental results.
关键词:
Numerical simulation
,
null
,
null
,
null
Xifeng LI
,
Kaifeng ZHANG
,
Changli WANG
,
Wenbo HAN
,
Guofeng WANG
材料科学技术（英文）
The amorphous Fe78Si9B13 ribbons were bend stress relaxed at various temperature well below the crystallization temperature (Tx) for different time. The effect of pre-annealing on the subsequent bend stress relaxation was examined. The variation of the microstructure and microhardness during bend stress relaxation process was studied using X-ray diffraction (XRD), atomic force microscopy (AFM) and Vickers microhardness test, respectively. Curvature radius of the amorphous Fe78Si9B13 ribbons decreased with increase bend stress relaxation temperature and time. The microhardness of the stress relaxed specimens increased with time at 300℃ due to the forming of nanocrystals during bend stress relaxation. The pre-annealing reduced the decrease rate of the curvature radius of stress relaxed specimens.
关键词:
Bend stress relaxation
,
null
,
null
,
null
Guoqing CHEN
,
Kaifeng ZHANG
,
Wenbo HAN
,
Junting LUO
材料科学技术（英文）
A series of alumina-zirconia composites with various grain sizes were prepared from the nano-sized powders with different agglomerations. Microstructural analysis of the sintered compacts indicates that the as-sintered material is a typical intra/inter granular nanocomposite with uniform distribution of the zirconia grains in the alumina matrix. Superplastic deep drawing test under different conditions demonstrates that dense Al2O3/ZrO2 samples with average grain size of 230 nm can be elongated to a dome height of at least 12 mm at the punch rate of 0.6 mm•min-1 at 1400℃. Further drawing tests show that for the composites with larger grain size, such elongation cannot be achieved at such a strain rate.
关键词:
Nanocomposite
,
null
,
null
,
null
Kaifeng ZHANG
,
Deliang YIN
,
Guofeng WANG
,
Wenbo HAN
材料科学技术（英文）
Superplasticity of AZ31 Mg alloy at the temperature range of 250~450℃ and stain rate range of 0.7×10-3~1.4×10-1 s-1 was examined through uniaxial tensile test. Optical microscopy (OM) and scanning electron microscopy (SEM) were employed to investigate the morphology of cavities and surface relief near fracture surface, respectively. It is shown that AZ31 Mg alloy starts to exhibit superplasticity from 300℃. The maximum elongation of 362.5% was obtained at 400℃ and strain rate of 0.7×10-3 s-1. There exist many O-shaped cavities and filaments at the boundaries near fracture surface. The fracture of filaments results in intergranular cavity and the model for the formation of intergranular cavities is proposed. The growth of cavities is plasticity-controlled and the serrated boundaries of intergranular cavities agree with the results of surface relieves.
关键词:
AZ31 magnesium alloy
,
null
,
null
,
null
郑桂丽
,
姜丽
,
张志东
液晶与显示
doi:10.3969/j.issn.1007-2780.2010.06.001
根据Erickson-Leslie流体动力学理论,研究了混合排列向列相-共面转换液晶盒的引流效应.在强锚定边界条件下,经过理论推导,得出液晶指向矢与流速的关系方程,进一步通过数值计算得出指向矢分布与时间的关系.发现引流效应加快了指向矢达到平衡态的速度,而且破坏了指向矢分布的瞬态对称性,特别在加电压的初始几毫秒这种现象非常明显.
关键词:
混合排列向列相
,
共面转换
,
引流效应
,
指向矢分布
余永刚
,
王玉强
,
周彦煌
,
陆欣
工程热物理学报
为了探索液体火箭发动机的新型点火方法,设计了一种周期性序列脉冲放电火花的模拟点火装置,该装置采用电机驱动电极转动,在圆周上形成放电火花的时空分布.采用高速录像系统,开展了HAN基液体推进剂LP1846液雾在不同条件下电点火特性的实验研究,结果表明,电极转速在3-5 r/s时,电火花在圆周放电空间内的分布比较密集,电能时空分布比较均匀,LP1846液雾点火效果较好.喷雾场流速、液雾细度与周向放电火花能量分布存在一个最佳匹配关系.
关键词:
液体推进剂
,
喷雾
,
电点火
,
瞬态测量
