Xiangting DONG
,
Guangyan HONG
材料科学技术（英）
A series of rare earth hydroxide and oxide nanoparticles have been prepared by precipitation method with alcohol as the dispersive and protective reagent. Transmission electron microscope (TEM) images indicate that the particles are spherical in shape and smaller than 100 nm in size. The crystallite sizes of cubic Ln2O3 have lanthanide shrinking effect, while average crystal lattice distortion rates possess lanthanide swelling effect. The diffraction peak intensity of heavy rare earth oxide nanometer powders is remarkably stronger than that of light rare earth oxide nanometer powders. The variation of diffraction intensity with atomic number presents an inverted W type, forming a double peak structure. Fourier transform infrared (FTIR) spectrums reveal that Ln2O3 nanopowders have higher surface activity than that of ordinary Ln2O3 powders. The UV-vis spectra show that Ln-O bond of these particles is slightly blue-shifted, and its absorption intensity decreases.
关键词:
Rare earth
,
null
,
null
,
null
,
null
Quan'an LI
,
Yungui CHEN
,
Mingjing TU
材料科学技术（英）
Effect of stoichiometry on microstructures, electrochemical properties and PCT characteristics of the alloys Ml(Ni0.71Co0.15-Al0.06Mn0.08)x (Ml=Lanthanum-rich Michmetal, x=4.6-5.2) have been investigated. The lattice constants a, c and cell volumes of non-stoichiometric alloys are bigger than those of the stoichiometric alloy. With the increasing stoichiometry x, the value of a decreases, and the value of c and cell volume increases except for those of the stoichiometric alloy; the plateau pressure of PCT curve, discharge capacity and cycling stability all increase. The alloy with x=5.2 shows the highest discharge capacity and the best cycling stability among the studied alloys.
关键词:
Hydrogen storage alloy
,
null
,
null
,
null
,
null
彭洪根
,
应家伟
,
张景岩
,
张先华
,
彭程
,
饶成
,
刘文明
,
张宁
,
王翔
催化学报
doi:10.1016/S1872-2067(16)62532-9
甲醛是室内装修污染的重要组分,已严重危害到人们身体健康,在室温条件下消除甲醛引起了人们的广泛兴趣.目前室温清除甲醛主要有物理吸附法、光催化法、等离子体技术及催化氧化技术.物理吸附法主要采用活性炭等作为吸附剂,其初期吸附效果较好,但当吸附饱和之后会重新释放甲醛造成二次污染;光催化法和等离子体技术需要特殊装置,不适合室内室温环境脱除甲醛;而催化氧化技术则可直接将甲醛转化为无毒无害的水和CO2,因而备受关注.Pt/TiO2被认为是目前消除甲醛最有效的催化剂.为进一步降低贵金属Pt的用量及增强其稳定性(Pt被氧化后其活性会降低),本文首次采用稀土La掺杂锐钛矿型TiO2,负载少量Pt后用于室内低浓度(0.5 ppm)甲醛的催化氧化.活性测试结果表明,纯TiO2催化剂上甲醛转化率在5%以下,有可能是物理吸附或可见光催化所致.负载0.5%Pt后,Pt/TiO2和Pt/La-TiO2甲醛转化率均高于80%,尤其是La掺杂活性高达96%以上,且在连续反应8 h甚至延长至40 h后其活性均未见下降趋势.电镜结果表明,La掺杂Pt/La-TiO2催化剂中Pt粒径从未掺杂的2.2 nm降至1.7 nm;CO程序升温脱附测试表明,Pt/La-TiO2/Pt的分散度达66%,而未掺杂样品仅为51%;X射线光电子能谱测试表明,Pt/La-TiO2的表面氧物种高于Pt/TiO2催化剂,说明La掺杂增强了Pt和载体间的相互作用.为探讨Pt/La-TiO2商业化应用前景,将粉体Pt/La-TiO2涂覆在堇青石蜂窝陶瓷上制备成整体催化剂.该整体催化剂在容积为2 m3的密室测试中5 min内即可将浓度为0.5 ppm的甲醛将至0.02 ppm以下.该催化剂在存放3个月后活性略有下降,但在10 min内仍可将甲醛浓度降至0.08 ppm,达到室内甲醛排放标准.综上,本文成功制备了La掺杂Pt/La-TiO2用于室内低浓度甲醛催化氧化,该催化剂表现出优异的催化性能.通过多种表征手段表明,La修饰后贵金属Pt纳米粒子尺寸减小、分散度提高及Pt与载体间相互作用增强是其活性优异的主要原因.以Pt/La-TiO2粉体制备的整体催化剂同样表现出了高的催化性能,具有工业应用前景.
关键词:
低浓度甲醛
,
室温氧化
,
稀土
,
镧掺杂
,
铂
,
二氧化钛
,
整体催化剂
Kun YU
,
Wenxian LI
,
Songrui LI
材料科学技术（英）
The Mg-MM and Mg-Nd master alloys were prepared through the ingot metallurgy method under the protection of a special flux. The thermodynamic behaviors of different rare earth elements in the molten Mg alloys were investigated. Two experimental alloys,Mg-3.0 wt pct MM-0.7 wt pct Zn-0.7 wt pct Zr and Mg-2.8 wt pct Nd-0.7 wt pct Zn-0.7~wt pct Zr, were prepared. The hardness and tensile properties of experimental alloys were measured and the microstructures were observed. The results showed that the rare earth elements could react greatly with the Mg chloride in the flux. The Mg-Nd-Zn-Zr alloy displayed a good aging hardening effect. The dispersed metastable phase β'(Mg3Nd) is an important strengthening phase to improve the tensile properties of this alloy. So the Mg-Nd-Zn-Zr alloy has better tensile properties and elongation than those of the Mg-MM-Zn-Zr alloy, and the ductile fracture character could be observed. The microvoid coalescence is the dominant fracture mechanism in this alloy.
关键词:
Mg-RE-Zn-Zr alloy
,
null
,
null
于善青
,
田辉平
催化学报
doi:10.1016/S1872-2067(14)60149-2
以三甲基磷氧(TMPO)和三丁基磷氧(TBPO)为探针分子,用31P魔角旋转核磁共振(31P MAS NMR)法对稀土改性Y型分子筛的酸性进行了定性和定量分析。结果表明,以TMPO为探针分子的31P MAS NMR谱分别在δ=78,70,65,62,58,55和53处存在与酸中心相关的吸收峰,其中δ=78和70处吸收峰与分子筛内部和外部酸性有关,δ=65,62,58和53处吸收峰归属于TMPO在分子筛内部Br?nsted酸中心上的贡献,δ=55处吸收峰归属于TMPO在分子筛内部Lewis酸中心上的贡献。随着稀土含量的增加,中等强度Br?nsted酸中心(δ=62和58)数量显著增加,而强Br?nsted酸中心(δ=65)和较弱Lewis酸中心(δ=55)数量显著降低。结合分子筛骨架铝和非骨架铝对分子筛酸性的影响进一步探讨了稀土改型Y分子筛的酸性。
关键词:
Y型分子筛
,
稀土
,
酸性
,
31P核磁共振
